Plane crash map Locate crash sites, wreckage and more

N62905 accident description

Alaska map... Alaska list
Crash location 61.125278°N, 149.748889°W
Nearest city Anchorage, AK
61.218056°N, 149.900278°W
8.2 miles away
Tail number N62905
Accident date 10 Sep 2016
Aircraft type HEFTY Polar Cub
Additional details: None

NTSB Factual Report

HISTORY OF FLIGHT

On September 10, 2016, about 1630 Alaska daylight time, a float-equipped, experimental amateur-built, Hefty Polar Cub airplane, N62905, was destroyed following a loss of control and subsequent impact with tree-covered terrain in a residential neighborhood in Anchorage, Alaska. The private pilot, the sole occupant, was fatally injured. The airplane was registered to and operated by the pilot as a personal local flight under the provisions of 14 Code of Federal Regulations Part 91. Visual meteorological conditions prevailed, and no flight plan was filed. The flight reportedly originated in southwest Anchorage from Jewell Lake about 1500, but the actual departure time and flight route are unknown.

According to family and friends of the pilot, the purpose of the flight was to fly over a proposed hunting site near Willow, Alaska, and then return to Anchorage. The friend related that the pilot and a group of friends were planning a fly-in hunt later in the week.

During on-scene interviews conducted by the National Transportation Safety Board (NTSB) investigator-in-charge (IIC) on the day of the accident, multiple witnesses consistently reported that they observed the airplane complete two, low-level, high-speed, 360° right turns over a residential neighborhood. The witnesses said that the airplane's first 360° turn was accomplished at an altitude between 150 and 200 ft above ground level, but the second turn was much lower. One homeowner stated that, as the airplane passed over his home, it was about 50 ft above his roofline. The witnesses also reported that the airplane's bank angle increased significantly on the second 360° right turn. One pilot-rated witness estimated that the airplane's bank angle was in excess of 60° during the second 360° turn. Multiple witnesses reported hearing the airplane's engine operating in a manner consistent with high power settings throughout both 360° turns.

Witnesses near the accident site reported that, as the airplane completed the second, steep, 360° right turn, the nose of the airplane pitched down, and it began a rapid nose-down descent. The engine rpm then increased significantly, and the wings rolled level just before the airplane impacted a stand of tall trees adjacent to a home. During the collision sequence, the airplane's floats were severed, and the airplane subsequently descended onto a neighborhood road, coming to rest inverted. A postimpact fire ensued about 30 seconds after impact, which quickly engulfed the entire airplane.

During a brief on scene interview with the NTSB IIC, a family member, along with a friend of the pilot, both reported that it was highly unusual and uncharacteristic behavior for the pilot to be flying as witnesses described.

PERSONNEL INFORMATION

The pilot, age 75, held a private pilot certificate with an airplane single-engine land rating; he did not hold a single-engine sea rating. In addition, he held a Federal Aviation Administration (FAA) repairman certificate specifically for the accident airplane. The pilot's most recent third-class, special issuance medical certificate, was issued on May 23, 2007, and contained the limitation: "Not valid for any class after May 31, 2008."

On the pilot's application for medical certificate, dated May 23, 2007, he indicated that his total aeronautical experience was about 2,200 flight hours. No personal flight records were located for the pilot.

AIRCRAFT INFORMATION

The airplane, which bears a resemblance to a Piper PA-11, had a rectangular, welded steel-tube structure that was covered with fabric. The wings, rudder, and horizontal stabilizer were all fabric covered. At the time of the accident, the airplane was equipped with a set of EDO 2000-series floats.

According to archived documents on file with the FAA certification office located in Oklahoma City, the airplane was built by the pilot from a set of purchased plans and was issued an FAA experimental airworthiness certificate with operating limitations on May 22, 1996. At the time the airworthiness certificate was issued, the airplane was equipped with a Continental Motors C-90-12-F engine.

At the time of the accident, the airplane was equipped with a Lycoming O-320-A2A engine, serial number L-9126-27, and a Catto composite propeller. No installation documentation for either the engine or propeller was located.

No aircraft maintenance records were located for the accident airplane. According to family members of the pilot, the airframe and engine logbooks were likely on board the airplane at the time of the accident. According to a family friend, the accident pilot performed all of the maintenance on the accident airplane.

METEOROLOGICAL INFORMATION

The closest official weather observation station to the accident site was located at the Ted Stevens Anchorage International Airport, about 10 miles to the east. On September 10, 2016, at 1553, the station was reporting, in part: wind 230° at 4 knots; visibility 10 statute miles; ceiling and clouds, few at 2,500 ft; temperature 63° F; dew point 43° F; altimeter 30.14 inches of mercury.

WRECKAGE AND IMPACT INFORMATION

Responding fire department and police personnel reported that, upon arrival, they discovered the inverted and burning wreckage on a neighborhood road, which was surrounded by tall trees. All of the airplane's major components were found at the main wreckage site. The airplane's longitudinal axis was oriented on a heading of 035° magnetic. Flight control continuity was established from the respective flight controls to the cabin area.

The airplane's first impact point was a stand of tall spruce trees about 120 ft from the wreckage point of rest. Broken tree branches and small portions of aircraft fabric that remained in the treetops marked the area.

The next impact point was a second stand of tall trees about 100 ft from the wreckage point of rest. The airplane's two EDO 2000-series floats were found entangled and suspended in the stand of tall trees.

The right wing was displaced slightly aft of its normal orientation to the fuselage, and the fabric on the underside of the wing was burned away. The aileron and flap remained attached to the wing, and the right flap appeared to be up. The leading edge of the right wing was slightly crushed and flattened in an aft direction, from about midspan to the wingtip. The inboard end of the wing and the right fuel tank were fire damaged.

The left wing was displaced aft about 45° from its normal orientation to the fuselage, and most of the fabric had burned away. The aileron and flap remained attached to the wing, and the left flap appeared to be up. The leading edge at the outboard end of the wing was flattened and crushed aft, with downward curling of the wingtip. The inboard end of the wing was extensively fire damaged, and the left fuel tank was incinerated.

The entire cockpit, baggage area, and fuselage extending to the vertical stabilizer were consumed by fire. Both wing lift struts remained attached to their respective wing and fuselage attach points.

The propeller hub assembly remained connected to the engine crankshaft, but the composite propeller blades were obliterated due to impact damage. The engine had impact and fire damage to the underside and front portion. Continuity of the drive train was established at the tachometer drive fitting on the accessory case when the propeller hub was moved by hand. The engine's four sparks plugs were examined and were dry with no unusual combustion signatures. The carburetor received impact damage. The engine control cables were either attached, or broken, at their respective carburetor control arms.

MEDICAL AND PATHOLOGICAL INFORMATION

A postmortem examination of the pilot was conducted under the authority of the Alaska State Medical Examiner, Anchorage, Alaska. The cause of death for the pilot was attributed to blunt force injuries. The autopsy also identified extensive lacerations of the aorta, heart, and liver. There was no soot identified in the tracheobronchial tree.

The FAA Bioaeronautical Sciences Research Laboratory performed toxicological examinations, which revealed 48% carboxyhemoglobin (carbon monoxide) in the pilot's blood. Additionally, amlodipine, metoprolol, naproxen, and rosuvastatin were detected in the pilot's blood and urine.

Carbon monoxide is an odorless, tasteless, colorless, nonirritating gas formed by hydrocarbon combustion. Carbon monoxide binds to hemoglobin with much greater affinity than oxygen, forming carboxyhemoglobin; elevated levels result in impaired oxygen transport and utilization. Early symptoms of carbon monoxide exposure may include headache, malaise, nausea, and dizziness. Carboxyhemoglobin levels between 10% and 20% can result in confusion, impaired judgment, and difficulty concentrating.

Nonsmokers may normally have up to 3% carboxyhemoglobin in their blood; heavy smokers may have levels of 10% to 15%. Family members and friends reported that the pilot was a nonsmoker.

Amlodipine is a prescription blood pressure medication also called Norvasc. Metoprolol is a beta blocking prescription medication, often called Lopressor or Toprol, that is used to treat high blood pressure and to prevent heart attacks in patients with coronary artery disease. Naproxen in an anti-inflammatory analgesic available over the counter with a variety of names, including Aleve. Rosuvastatin is a prescription medication to treat high cholesterol and is commonly marketed with the name Crestor. None of these medications adversely affect performance.

According to the NTSB chief medical officer's review of the pilot's autopsy and medical records obtained from the Veteran's Administration Hospital, Joint Base Elmendorf-Richardson, Anchorage, he had a history of hypertension, high cholesterol, coronary artery disease, and bladder neck obstruction. A copy of the NTSB' chief medical officer's factual report is available in the public docket for this accident.

TESTS AND RESEARCH

On December 2, 2016, after being notified by the FAA's Bioaeronautical Sciences Research Laboratory of the elevated level of carboxyhemoglobin in the pilot's blood, the NTSB IIC recovered the accident airplane's exhaust system for a detailed examination. The airplane's exhaust system consisted of a muffler covered by an exterior shroud assembly that provided ducted heat to the airplane's cockpit, cabin, and engine carburetor heat system. During the exhaust system examination, the NTSB IIC peeled open the shroud assembly, which revealed a severely degraded and damaged muffler can assembly. The muffler can was cracked around most of its circumference near the inlet portion of the muffler. The entire muffler assembly was then sent to the NTSB's Materials Laboratory for further examination.

The examination revealed that portions of the muffler can material were missing and that areas adjacent to the missing material had white, oxidized exhaust deposits. Cracks and corrosion on the interior surface of the exterior shroud in an area under a riveted doubler were also seen. A copy of the NTSB's Materials Laboratory Factual Report is included in the public docket for this accident.

ADDITIONAL INFORMATION

FAA Advisory Circular (AC) 91-59A, "Inspection and Care of General Aviation Aircraft Exhaust Systems," emphasizes the safety hazards of poorly maintained aircraft exhaust systems and highlights points at which exhaust system failures occur. In addition, the AC stresses the importance of having carbon monoxide detection equipment installed. Due to the extensive postcrash fire damage to the airplane, the NTSB was unable to determine if the accident airplane was equipped with any type of carbon monoxide detection equipment.

NTSB Probable Cause

The pilot's severe impairment from carbon monoxide poisoning in flight, which resulted in a loss of control and a subsequent collision with trees and terrain.

© 2009-2020 Lee C. Baker / Crosswind Software, LLC. For informational purposes only.