NTSB Factual Report

HISTORY OF FLIGHT

On April 21, 2010, about 0936 Hawaiian standard time, an AirBorne WindSport Edge XT-912-L weight-shift-control light sport aircraft, N34TH, was substantially damaged when it impacted the water of Kealakekua Bay near Captain Cook, Hawaii. The light-sport pilot and his student sustained fatal injuries. The pilot was doing business as Tedd’s Flying Adventures and operating the aircraft under the provisions of 14 Code of Federal Regulations Part 91. Visual meteorological conditions prevailed for the instructional flight. A flight plan had not been filed. The aircraft departed from Kona International Airport, Kailua Kona, Hawaii, at 0912.

According to Federal Aviation Administration Air Traffic Control personnel, the accident aircraft made its first departure for the day at 0748 and returned at 0814. The passenger on the second (accident) flight had flown with the pilot once before; this ride was given to her as a birthday gift.

According to witnesses, the aircraft was maneuvering near a 450-foot-tall cliff, which descended directly into the ocean. Several witnesses estimated that the aircraft was between 300 and 400 feet above the water; one witness estimated that it was only about 100 feet above the water. The aircraft approached the cliff flying on a northwesterly heading and about a 45-degree intercept to the cliff. As it flew very close to the cliff, it banked left and “flipped over.” The witnesses heard a loud popping sound, the wings folded around the fuselage (pod) and the aircraft descended in a spiraling corkscrew-like manner. One witness said that it looked "like a butterfly landing on a flower." The aircraft impacted the surface of the bay about 100 to 300 feet from the base of the cliff and sank immediately.

There were several snorkel tour boats in the area and two of the snorkel tour guides dove into the gasoline covered water. They recovered the two occupants, and the boats took the occupants to a boat ramp about a mile away where Fire and Rescue personnel took over.

PERSONNEL INFORMATION

The 38-year-old pilot held a private pilot certificate with an airplane single engine land rating obtained in December 2002, and a light sport pilot certificate with a weight-shift-control rating obtained in March 2009. He became an instructor in weight-shift-control aircraft 8 months later on November 1, 2009. At the time of the accident, his pilot logbook and other records indicate that he had 375 hours of total flight time.

AIRCRAFT INFORMATION

The single-engine (pusher), propeller-driven, two seat (in line) weight-shift-control aircraft was manufactured by AirBorne WindSports Pty. Ltd., Redhead, New South Wales, Australia, in October 2009. Its maximum takeoff gross weight was 992 pounds. It was powered by a Rotax 912 UL four-stroke engine, which had a maximum output of 80 horsepower. This two seat design had a pilot-passenger “pod” suspended by a triangular frame, hinged below a strutted wing, which permitted weight shift control of pitch and roll axes. It was equipped with dual flight controls.

The manufacturer of the aircraft had published a Pilot’s Operating Handbook (POH), which included Operational Limits for the aircraft. This section included the following statement concerning maneuvering limits:

“All aerobatic maneuvers including spinning is prohibited.

Aerobatic maneuvers including whipstalls, stalled spiral descents and negative G maneuvers are not permitted. It must be emphasized that a whipstall, spiral descent or negative G maneuvers can never be conducted safely. These maneuvers put the aircraft outside the pilots control and put both the aircraft and its occupants in extreme danger.

Do not pitch nose up or nose down more than 45 degrees from the horizontal. The front support tube of the trike [aircraft] and the pilot’s chest limits the fore and aft movement of the control bar respectively.

BANK ANGLE

Do not exceed 60 degrees of bank angle. In roll there is no stop for the control movement. For the purpose of pre-flight freedom, check by lowering each wing to within 10 cm of the ground (on ground level).”

Additionally, the POH stated that flight load factors are limited to 4.0 “G” positive, load factors from 1.0 “G” positive to 0.0 “G” should be avoided, and any negative loads (less than 0.0 “G”) are prohibited.

The U.S. representative for AirBorne WindSports stated that he assembled the aircraft in Hawaii for the owner. He said the aircraft came with the necessary hardware to mount a recovery parachute, but the pilot/owner asked him to leave the hardware off. The representative also stated that he never saw an aircraft parachute amongst the pilot/owner’s equipment.

Review of the website for Tedd’s Flying Adventures indicated that it stated that the aircraft was equipped with a recovery parachute; however, the photos of the aircraft displayed on the website show that a parachute was not installed. Passengers in the aircraft were provided with a helmet/headset combination with noise canceling capabilities, which provided communication between the two occupants. Each occupant was provided with an automatic inflatable personal flotation device.

According to the aircraft’s maintenance records, the last 100-hour maintenance inspection was completed on April 9, 2010, at an aircraft total time of 100 hours.

METEOROLOGICAL INFORMATION

At 0953, the reported weather conditions at Kona International Airport (elevation 47 feet), Kailua Kona, located 17 nautical miles north of the accident site were: wind from 270 degrees at 6 knots; visibility 10 statute miles; clear of clouds; temperature 77 degrees Fahrenheit; dew point 61 degrees Fahrenheit; altimeter setting 30.09 inches of Mercury. The captain of one of the snorkel tour boats, who witnessed the accident, stated that the weather was sunny, the ocean was very calm, and the wind was less than 5 knots.

WRECKAGE AND IMPACT INFORMATION

The initial impact of the aircraft was in the Pacific Ocean. The aircraft was never recovered.

MEDICAL AND PATHOLOGICAL INFORMATION

An autopsy of the pilot was conducted by Pan Pacific Pathologists, LLC, at the Kona Community Hospital, Kealakekua, Hawaii, on April 21, 2010.

The FAA’s Civil Aeromedical Institute (CAMI), Oklahoma City, Oklahoma, performed toxicology tests on the pilot. According to CAMI’s report, the pilot’s blood was tested for carbon monoxide and cyanide with negative results. Additionally his vitreous fluid was tested for volatiles with negative results, and his urine was tested for drugs with negative results.

ADDITIONAL INFORMATION

According to Federal Aviation Administration regulations, Title 14: Aeronautics and Space, Part 91.327, Aircraft having a special airworthiness certificate in the light-sport category: Operating limitations.

(a)No person may operate an aircraft that has a special

airworthiness certificate in the light-sport category for

compensation or hire except---

(1)To tow a glider or an unpowered ultralight vehicle in

accordance with 91.309 of this chapter; or

(2)To conduct flight training.

NTSB Probable Cause

The pilot’s intentional in-flight maneuvers that exceeded the structural limits of the aircraft, which resulted in structural failure of the wings.