NTSB Factual Report

The Safety Board's full brief is available at http://ntsb.gov/Publictn/publictn.htm. The Aviation Accident Brief number is NTSB/AAB-07/04.

HISTORY OF THE FLIGHT

On January 10, 2005, about 2311 eastern standard time, [1] a Eurocopter Deutschland GmbH EC-135 P2 helicopter, N136LN, operated by LifeNet, Inc., as Life Evac 2, crashed into the Potomac River during low-altitude cruise flight near Oxon Hill, Maryland. The certificated commercial pilot and the flight paramedic were killed, and the flight nurse received serious injuries. The helicopter was destroyed. The positioning flight was conducted under the provisions of 14 Code of Federal Regulations (CFR) Part 91 and visual flight rules (VFR) with a company flight plan filed. Night visual meteorological conditions prevailed at the time of the accident.

The flight originated at the Washington Hospital Center Helipad (DC08), Washington, D.C., about 2304, and was en route to Stafford Regional Airport (RMN), Stafford, Virginia. Global positioning system (GPS) data for the flight [2] showed that the helicopter proceeded toward the Federal Aviation Administration's (FAA) published helicopter route 1. [3] According to FAA air traffic control (ATC) transcripts, the pilot contacted the local controller at Ronald Reagan Washington National Airport (DCA), Washington, D.C., at 2305:47 and stated, "washington tower life evac two . . . sir we're at uh medstar like to go out to uh r f k route one then to route four south." The local controller responded, "life evac two (unintelligible) bravo airspace altimeter three zero two five." The pilot responded, "roger understand cleared as requested."

Examination of FAA ATC radar data showed that the helicopter intercepted a segment of published helicopter route 1, followed it southwest to intercept helicopter route 4, and then flew southbound along the Potomac River toward Woodrow Wilson Bridge. As the helicopter flew over the river toward Woodrow Wilson Bridge, its Mode C transponder reported that its altitude varied from 0 to 100 feet. [4] When the helicopter was about 0.5 nautical mile (nm) north of the bridge, its reported Mode C altitude was 200 feet.

At 2311:20, the pilot reported to the local controller, "life evac two is at the Woodrow Wilson [Bridge]," and the controller responded, "life evac two washington tower traffic on a ten mile final is a seven [sic] an airbus." [5] At 2311:30, the pilot responded, "roger we have him in sight and will be out of his way," and the controller stated, "life evac two maintain visual separation from traffic." ATC radar data showed that, at the time of the pilot's response, the helicopter was about 0.25 nm north of the Woodrow Wilson Bridge at an altitude of about 200 feet. The pilot made no further radio communications.

According to the flight nurse, who was seated in the helicopter's left front copilot's seat, the pilot maneuvered the helicopter to cross the bridge midspan. The flight nurse stated that the helicopter appeared to be at the same or higher altitude than the lights he saw on some construction cranes near the Woodrow Wilson Bridge. He stated that he "called the lights" on both sides of the river to the pilot and that the pilot acknowledged him. According to a Maryland Department of State Police report, the flight nurse also stated that there was a "commercial airplane coming into [DCA], and the pilot . . . made a change in his flightpath and started to descend." [6]

According to ATC radar data, at 2311:39, the helicopter had crossed over the Woodrow Wilson Bridge and was just south of the bridge with a ground track of about 180 degrees and an altitude of about 200 feet. Four seconds later, the helicopter had a ground track of about 190 degrees and an altitude of about 100 feet. The helicopter's last recorded position at 2311:48 showed a ground track of about 200 degrees and an altitude of about 0 feet. According to ATC radar data, at the time of the helicopter's last radar return, the northbound Airbus that the local controller previously mentioned was about 2.2 nm south of the helicopter's position at an altitude of about 1,700 feet.

According to the flight nurse, after the helicopter flew over the southern half of the Woodrow Wilson Bridge, the next thing he recalled was being submerged in water with his seatbelt on and his helmet off. He stated that the helicopter's master caution lights and panel segment lights did not illuminate and that he did not hear any audio alarms sound before the crash. He stated that the pilot did not execute any evasive maneuvers or communicate any difficulties, either verbally or nonverbally.

According to witnesses in vehicles on the Woodrow Wilson Bridge, the helicopter crossed over the bridge before it descended and then impacted the water. None of the witnesses reported seeing the helicopter impact any objects before its descent. The wreckage was located in the Potomac River about 0.5 nm south of the Woodrow Wilson Bridge.

At 2314:46 (about 3 minutes after the helicopter crashed), the DCA local controller stated, "life evac two frequency change approved." The controller received no reply and made no further attempts to contact the flight. The Maryland State Police later notified the controller of the crash.

PILOT INFORMATION

The pilot, age 56, was hired by LifeNet in June 2004. He held a commercial pilot certificate with ratings for airplane single- and multi-engine land, rotorcraft helicopter, and instrument helicopter. His most recent FAA second-class airman medical certificate was issued on May 28, 2004. On his application for the medical certificate, he reported 1,500 hours total civilian flight experience, 30 hours of which were accumulated in the previous 6 months. [7] A review of company records showed that, in the 90 days, 30 days, and 24 hours before the accident, the pilot flew 42 hours, 12 hours, and 1 hour, respectively, and performed a total of 71 night landings.

According to LifeNet's training records, during the pilot's first few weeks of employment, the company provided 12 hours of basic indoctrination training, as well as 20 hours of initial ground training and 7.8 hours of flight training in the Messchersmitt Bolkal Blohm BK-117 helicopter. The training records indicated that the pilot completed the initial pilot-testing requirements of 14 CFR 135.293 and the pilot-in-command flight check required by 14 CFR 135.299 on July 8, 2004, in the BK-117. The company subsequently provided the pilot 18 hours of transition ground training and 5.8 hours of transition flight training for the EC-135, and the pilot completed the initial testing and flight-check requirements in the EC-135 on October 3, 2004.

During his employment with LifeNet, the pilot accumulated 51.5 flight hours in the BK-117 and 40.8 flight hours in the EC-135. According to LifeNet's assistant chief pilot, when the pilot applied for employment, he reported that he had been retired since 1997 but that he was current for Part 135 operations and had passed Part 135 flight checks in a Bell 206 helicopter in February 2004 and in a BK-117 in April 2004. The assistant chief pilot stated that, according to the pilot's interview and resume, he had been a military pilot in the U.S. Army from 1968 to 1971 and had accumulated about 2,400 military flight hours in helicopters, including about 350 hours of night flying and about 70 hours of instrument flying. From 1971 to his retirement in 1997, the pilot worked for a corporation in both nonflying and flying positions. During his 26-year corporate employment, the pilot accumulated 400 hours total flight experience in Agusta 109 and Sikorsky S76 helicopters and about 300 total civilian flight hours in fixed-wing airplanes.

The resume that the pilot submitted to LifeNet did not list his most recent employer, which was another Part 135 helicopter operator that had terminated his employment after about 2 weeks. According to the chief pilot for that company, the accident pilot was hired on April 12, 2004, but the company terminated his employment on April 28, 2004, because the pilot was unable to adequately perform complex tasks in the helicopter or fly a "complete mission" involving several tasks in a series. [8] During his training with this operator, the pilot accumulated about 7 hours of flight time in a BK-117.

Two medical crewmembers who flew with the pilot the night before the accident on the same route as the accident flight and on other previous flights stated that the pilot flew the helicopter in a manner equivalent to other pilots in the company.

HELICOPTER INFORMATION

The helicopter was manufactured in 2004 and was equipped with two Pratt & Whitney Canada PW206B-series turboshaft engines. The helicopter was configured with a front right pilot seat, a front left copilot's seat, an aft-facing passenger seat in the left aft cabin, and an area for one medical patient in the aft cabin. Each seat was equipped with lap belt and shoulder harness restraints.

The helicopter was maintained in accordance with an FAA-approved aircraft inspection program. According to maintenance records, the most recent 50-hour inspection was performed on December 17, 2004. The most recent 100-hour inspection was performed on November 23, 2004, at an airframe total time of 94.5 hours. At the time of the accident, the helicopter had accumulated 166.6 total hours.

The maintenance logbook recovered from the helicopter included an entry dated January 10, 2005, for an inoperative radar altimeter. [9] The maintenance log also contained a "Record of Minimum Equipment List (MEL) Items and Deferred Maintenance" section that included an entry stating that the inoperative radar altimeter could be deferred for maintenance until January 20, 2005. [10]

METEOROLOGICAL INFORMATION

According to the DCA automated surface observing system, located about 3.5 nm north of the accident site, the reported conditions at 2251 were winds calm, visibility 10 statute miles, broken clouds at 13,000 feet and 20,000 feet, temperature 45 degrees Fahrenheit (F), dew point 36 degrees F, and altimeter setting 30.25 inches of mercury.

According to recorded astronomical data, at the time and location of the accident, a new moon was below the horizon and provided no illumination.

WRECKAGE AND IMPACT INFORMATION

The helicopter was recovered from about 5 feet of water in the Potomac River. Wreckage was scattered along a north-south oriented debris path. The wreckage was recovered, and examination indicated no evidence of a collision with a bird or other object, fatigue fractures, or other anomalies.

The main fuselage section was separated into the lower cockpit area and upper cockpit area. The lower cockpit area included the flight-crew floorboard section, antitorque pedals, the forward skid frame, and fragments of the fuel tank. The upper cockpit area included the flight-control tubes, the center electrical and flight-control structure, the upper flight-control deck, engines, the main transmission, and the rotor head.

The cyclic, collective, and antitorque control systems were damaged, and portions of some push-pull tubes were separated and not recovered. Continuity could not be established because of the separations; however, the separated surfaces showed fracture features consistent with impact-related overload.

The main rotor mast was in place and intact in the main transmission. The root ends of the four main rotor blades remained attached to the main rotor hub on the mast. Three of the four pitch-change links were connected to their two attach points, and the other pitch-change link was fractured in the middle. The fracture surfaces were consistent with compression-bending overload.

Portions of all four main rotor-blade tips were recovered. Each main rotor blade had overload fractures and chordwise scoring on the lower blade skin between 6 to 12 inches from the blade hub. Each blade also showed fractures along the blade span, consistent with impact damage. The main transmission remained attached to the center section of the upper airframe structure, and all four mounting points were intact. The main transmission turned freely, no chips were found on the detectors, and the transmission appeared intact and functional.

The tail boom was separated at the aft fuselage frame. The tail section included the complete fenestron assembly [11] with the tail rotor gearbox and tail rotor. The tail rotor driveshaft was displaced forward about 1.5 inches. The aft portion of the driveshaft, which was carbon composite, was found fractured, torsionally cracked, and deformed. All tail rotor blades remained complete and attached to the hub. The fenestron shroud around the tail rotor showed a rotational scrape at the 5 o'clock position. The width of the scrape corresponded with the tail rotor-blade width.

Both engines showed little damage, and the gas generator (N1 compressor and turbine) and power turbine (N2 turbine) for each engine rotated freely. Nonvolatile memory data extracted from the electronic engine control units for each engine revealed no evidence of preimpact faults.

MEDICAL AND PATHOLOGICAL INFORMATION

The FAA Bioaeronautical Sciences Research Laboratory, Oklahoma City, Oklahoma, performed toxicological testing on specimens from the pilot, and no drugs or alcohol were detected in the pilot's blood or urine.

SURVIVAL ASPECTS

The State of Maryland, Office of the Chief Medical Examiner, performed autopsies on the pilot and the flight paramedic. The medical examiner determined that the pilot's cause of death was "multiple injuries." The flight paramedic's cause of death was listed as "drowning complicated by hypothermia"; [12] the paramedic was found still belted into the left aft cabin seat.

According to the flight nurse, after the crash, he was submerged in water but was able to remove his seat restraints, exit the helicopter, and remain near the helicopter's partially submerged tail section until a rescue boat arrived. He was taken to a hospital and treated for a broken arm and burns.

Several of the witnesses who saw the helicopter impact the water telephoned 911 to report the crash. According to the DCA tower's daily record of operation, the DCA controller received a call about 2326 from a Maryland State Police helicopter crew advising that they were inbound to investigate reports of a downed aircraft near the Woodrow Wilson Bridge. According to an incident report from the City of Alexandria (Virginia) Fire Department, Station 201, the station was notified about the downed aircraft at 2330:18 and dispatched the first of nine emergency medical service apparatuses about 2331:12; the first boat was dispatched at 2333:09.

ORGANIZATIONAL AND MANAGEMENT INFORMATION

LifeNet's Part 135 certificate was issued in 1995. LifeNet is headquartered in Chesterfield, Missouri, and has 89 aircraft based at various locations across the country. LifeNet's fleet includes various AS-350, BK-117, and EC-135 series helicopters, various models of Bell helicopters, Eurocopter BO-105 helicopters, McDonnell Douglas MDHS-MD-900 helicopters, and Beech BE-100 and BE-200 twin-engine turboprop airplanes. LifeNet employs pilots and medical personnel.

TESTS AND RESEARCH

A National Transportation Safety Board performance engineer completed a performance study using the last 30 seconds of the flight's Mode C radar data and the location of the crash site to estimate the helicopter's bank angle and flightpath descent angle at impact, as well as the time of the crash. The study estimated that the helicopter's flightpath angle was about -3 degrees, its bank angle was about 12 degrees right, and it impacted the water about 3.5 seconds after the last radar return. [13]

The study also used primary and Mode C radar data to examine the helicopter's proximity to other aircraft and to evaluate any possible encounter with wake turbulence or a bird flock. [14] Review of the Mode C radar data showed that a 70-passenger Canadair Regional Jet 700 (CRJ-700) passed northbound over Woodrow Wilson Bridge about 1 minute 45 seconds before the helicopter passed over the bridge. According to the data, the helicopter passed 900 feet directly beneath the flightpath of the CRJ-700. On t

NTSB Probable Cause

The pilot's failure to identify and arrest the helicopter's descent, which resulted in controlled flight into terrain. Contributing to the accident were the dark night conditions, limited outside visual references, and the lack of an operable radar altimeter in the helicopter.